您好,歡迎光臨萊州中科聚峰有限公司網站! 主營自動攪拌車,攪拌一體車,自動上料攪拌車等各種規格的產品。
15098551508
自動上料攪拌車行業持續領跑者!
點擊撥打服務熱線:4008791999

您的位置:首頁 - 技術問答 > 行業資訊 >

行業資訊

自上料混凝土攪拌車燃油系統保養?

發布時間:2021-02-15 來源:http://www.pembeyol.com/ 瀏覽量:

概述:自上料混凝土攪拌車發動機能夠正常運轉,機器能夠高能進行作業,主要是依靠燃油系統提供動力。很多時候,機器發動機無法啟動或啟動無力,都
自上料混凝土攪拌車發動機能夠正常運轉,機器能夠高能進行作業,主要是依靠燃油系統提供動力。很多時候,機器發動機無法啟動或啟動無力,都是因為燃油系統出現了故障,所以,要做好燃油系統的日常保養。如何做好呢?
The engine of self loading concrete mixer can run normally, and the machine can work with high energy, mainly relying on the fuel system to provide power. Most of the time, the engine can't start or can't start because of the fault of the fuel system. Therefore, the daily maintenance of the fuel system should be done well. How to do it well?
1、及時加注燃油
1. Fill the fuel in time
小型自動上料攪拌車作業的過程中,操作人員要隨時關注燃油量。當燃油表顯示的燃油量接近“0”位時,一定要及時加注燃油。切忌等燃油用盡之后才添加,這樣做的后果不僅僅是造成柴油機無油后熄火,重要的是會導致空氣進入燃油系統。一旦燃油系統中進入了空氣,不僅浪費了燃油,而且排出去比較麻煩。
During the operation of small automatic feeding mixer, the operator should pay attention to the fuel quantity at any time. When the fuel quantity shown on the fuel gauge is close to "0", be sure to fill the fuel in time. Do not add the fuel until it is used up. The consequence of this is not only to cause the diesel engine to stop when there is no fuel, but also to cause air to enter the fuel system. Once the air enters the fuel system, it not only wastes the fuel, but also causes trouble in discharging it.
2、注意避免燃油系統堵塞
2. Pay attention to avoid fuel system blockage
我們都知道,有時候自動上料攪拌車的工作環境比較特殊,這樣就很容易導致燃油系統堵塞,一旦燃油系統堵塞,就會影響機器的正常運轉。所以要及時檢查確保燃油管道的通暢。
We all know that sometimes the working environment of the automatic feeding mixer is special, which can easily lead to the blockage of the fuel system. Once the fuel system is blocked, the normal operation of the machine will be affected. Therefore, it is necessary to check in time to ensure that the fuel pipe is unobstructed.
3、注意檢查燃油系統密封性
3. Pay attention to check the tightness of the fuel system
小型自動上料攪拌車作業的時候,如果發現排氣管冒黑煙,或是發動機出現啟動困難的狀況,有可能是因為漏氣,所以要注意檢查燃油系統的密封性。
During the operation of small automatic feeding mixer, if it is found that the exhaust pipe is emitting black smoke, or the engine is difficult to start, it may be due to air leakage, so pay attention to check the tightness of the fuel system.
            自動攪拌車
4、保持燃油的清潔
4. Keep the fuel clean
燃油系統的故障有大約50%是因為燃油不潔所造成,對于汽油機而言,絕大多數是因為燃油中混入水分,汽油中的水分還會腐蝕和破壞燃油供油系統元件。
About 50% of the faults in the fuel system are caused by unclean fuel. For gasoline engines, most of them are caused by water in the fuel, which will corrode and damage the components of the fuel supply system.
5、燃油選擇很關鍵
5. Fuel selection is key
建議選擇適合自動上料攪拌車的高品質燃油,質量較差的燃油過濾不良,油泥、雜質、水分,長期積累,沉淀下來,容易堵塞油泵濾網,油管及噴油嘴。
It is suggested that high quality fuel suitable for automatic feeding mixer should be selected. The fuel with poor quality has poor filtration, sludge, impurities and moisture can accumulate and precipitate for a long time, which is easy to block the filter screen, oil pipe and nozzle of oil pump.
自上料混凝土攪拌車這類卡車上都裝置圓筒型的攪拌筒以運載混合后的混凝土。在運輸過程中會始終保持攪拌筒轉動,以保證所運載的混凝土不會凝固。運送完混凝土后,通常都會用水沖洗攪拌筒內部, 防止硬化的混凝土占用空間。
Since the loading concrete mixer truck, such trucks are equipped with cylindrical mixing drum to carry the mixed concrete. During transportation, the mixing drum will always keep rotating to ensure that the concrete will not solidify. After the concrete is transported, the inside of the mixing drum is usually washed with water to prevent the hardened concrete from occupying space.
技術支持:濟南諾商  XML   TXT   
本網站部分資源來自互聯網,如有侵權,請聯系我們及時刪除
分享按鈕

截屏,微信識別二維碼

微信號:

點擊微信號復制,添加好友

 打開微信

日本阿v不卡高清在线播放_2019久久久高清456_被公每天都侵犯的我正在播放