您好,歡迎光臨萊州中科聚峰有限公司網站! 主營自動攪拌車,攪拌一體車,自動上料攪拌車等各種規格的產品。
15098551508
自動上料攪拌車行業持續領跑者!
點擊撥打服務熱線:4008791999

您的位置:首頁 - 技術問答 > 公司新聞 >

公司新聞

混凝土攪拌車如何保證混凝土的性能?

發布時間:2020-07-18 來源:http://www.pembeyol.com/ 瀏覽量:

概述:混凝土罐車即混凝土攪拌車,在混凝土攪拌站生產好混凝土時需要混凝土罐車將其快速運輸到施工現場進行澆筑施工。那么,混凝土罐車在運輸過程
混凝土罐車即混凝土攪拌車,在混凝土攪拌站生產好混凝土時需要混凝土罐車將其快速運輸到施工現場進行澆筑施工。那么,混凝土罐車在運輸過程中是如何保證混凝土的性能呢?
  The concrete tank truck is the concrete mixer. When the concrete is produced in the concrete mixing station, it needs to be quickly transported to the construction site for pouring construction. So, how to ensure the performance of concrete in the process of transportation?
  混凝土罐車驅動裝置的作用是驅動混凝土貯罐轉動,如果沒有做好維護,混凝土貯罐將不能轉動,這會導致車內混凝土報廢,嚴重的甚至使整罐混凝土凝結在罐內,因此,掌握混凝土攪拌站罐車驅動裝置維護方法很重要。
  The function of the driving device of concrete tank truck is to drive the concrete tank to rotate. If it is not well maintained, the concrete tank will not be able to rotate, which will lead to the scrapping of the concrete in the truck, and even make the whole tank concrete coagulate in the tank. Therefore, it is very important to master the maintenance method of the driving device of the tank truck in the concrete mixing station.
  維護要保證液壓油冷卻裝置有效。要定時清理液壓油散熱器,避免散熱器被水泥堵塞,檢查散熱器電動風扇運轉是否正常,防止液壓油溫度超標。液壓部分只要保證液壓油清潔,一般故障不多;但生產廠家不同,使用壽命則不一樣。
                自動攪拌車
  Maintenance to ensure that the hydraulic oil cooling device is effective. The hydraulic oil radiator should be cleaned regularly to prevent the radiator from being blocked by cement, and check whether the electric fan of radiator operates normally to prevent the temperature of hydraulic oil exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part, but the service life varies with the manufacturer.
  維護要重視萬向轉動部分,是故障多發部位,應按時加注潤滑脂,并經常檢查磨損情況,及時修理更換。車隊應有備用的萬向軸總成,以保證一旦發生故障能在幾十分鐘內恢復工作。
  The maintenance should pay attention to the universal rotation part, which is the fault prone part. Grease should be added on time, and the wear condition should be checked regularly, and the repair and replacement should be carried out in time. The team should have spare cardan shaft assembly to ensure that it can resume work in dozens of minutes in case of failure.
  維護要保證液壓油清潔?;炷翑嚢柽\輸車工作環境惡劣,一定要防止污水泥沙進入液壓系統。液壓油要按使用手冊要求定期更換。一旦檢查時發現液壓油中混入水或泥沙,就要立即停機清洗液壓系統、更換液壓油。
  Keep the hydraulic oil clean during maintenance. The working environment of concrete mixer truck is bad, so it is necessary to prevent dirty cement sand from entering the hydraulic system. The hydraulic oil should be replaced regularly according to the requirements of the manual. Once it is found that the hydraulic oil is mixed with water or sediment, it is necessary to stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
  還要做好混凝土攪拌站罐車輪胎的維修,才能真正正確的混凝土攪拌站罐車驅動裝置維護。
  In order to maintain the driving device of the tank car of the concrete mixing station, it is necessary to do a good job in the repair of the tire of the tank car in the concrete mixing station.
技術支持:濟南諾商  XML   TXT   
本網站部分資源來自互聯網,如有侵權,請聯系我們及時刪除
分享按鈕

截屏,微信識別二維碼

微信號:

點擊微信號復制,添加好友

 打開微信

日本阿v不卡高清在线播放_2019久久久高清456_被公每天都侵犯的我正在播放