您好,歡迎光臨萊州中科聚峰有限公司網站! 主營自動攪拌車,攪拌一體車,自動上料攪拌車等各種規格的產品。
15098551508
自動上料攪拌車行業持續領跑者!
點擊撥打服務熱線:4008791999

您的位置:首頁 - 技術問答 > 公司新聞 >

公司新聞

自拌混凝土攪拌車的斷氣剎與油剎有什么區別?

發布時間:2021-02-26 來源:http://www.pembeyol.com/ 瀏覽量:

概述:1、自拌混凝土攪拌車普通氣剎的駐車制動只能在貨車靜止的情況下使用,因為其制動力矩是作用在傳動軸上,如果在小型攪拌車行駛當中使用,容
1、自拌混凝土攪拌車普通氣剎的駐車制動只能在貨車靜止的情況下使用,因為其制動力矩是作用在傳動軸上,如果在小型攪拌車行駛當中使用,容易造成傳動軸和后橋的嚴重超載荷,還可能因差速器殼被抱死而發生左右兩車輪的旋轉方向相反,致使貨車制動時跑偏甚至掉頭。但儲能彈簧制動則不然,相反因為儲能彈簧駐車制動行程大于行車制動行程,在行車制動力不足的情況下,還可以使用儲能彈簧助力進行應急制動。所以儲能彈簧制動不僅可以作駐車制動,還可以作應急制動。所以斷氣剎式制動系統與普通氣剎相比,在制動穩定性和安全性方面更勝一籌。
1. The parking brake of the ordinary air brake of the self mixing concrete mixer can only be used when the truck is stationary, because its braking torque acts on the transmission shaft. If it is used in the driving of the small mixer, it is easy to cause serious overload of the transmission shaft and the rear axle, and the rotation direction of the left and right wheels may be opposite due to the locking of the differential housing, resulting in the deviation of the truck when braking Even a U-turn. But the energy storage spring braking is not the case. On the contrary, because the parking braking stroke of the energy storage spring is greater than the service braking stroke, in the case of insufficient service braking force, the energy storage spring can also be used for emergency braking. Therefore, the energy storage spring brake can not only be used as parking brake, but also as emergency brake. Therefore, compared with the ordinary air brake, the air break brake system is better in braking stability and safety.
           自動攪拌車
2、自拌混凝土攪拌車油剎結構簡單,安裝空間小,只是需要剎車總泵、分泵、油杯及連接管路,不需要其他的附屬設備;氣剎就復雜多了,除了剎車總泵、分泵、剎車管路外,還有打氣泵、儲氣筒、高壓控制器、繼動閥等部件,需要安裝空間大,結構較復雜,而且為了確保安全,后剎車分泵現在都是斷氣剎車。
2. The oil brake of self mixing concrete mixer has simple structure and small installation space. It only needs brake master cylinder, sub pump, oil cup and connecting pipeline, and does not need other auxiliary equipment; The air brake is much more complicated. In addition to the brake master cylinder, sub cylinder and brake pipeline, there are also air pump, air reservoir, high-pressure controller, relay valve and other components, which need large installation space and complex structure. In addition, in order to ensure safety, the rear brake sub cylinder is now air brake.
3、常規剎車是手剎鎖住傳動軸,腳剎時由壓縮空氣進入制動氣室鎖住車輪。在手剎或傳動軸機械故障時,手剎失靈;在氣泵、管路、儲氣筒、制動閥任何一個部位故障時,腳剎失靈。而斷氣剎車就可有效避免這些危險
3. The conventional brake is that the hand brake locks the transmission shaft, and when the foot brake, the compressed air enters the brake chamber to lock the wheel. In case of mechanical failure of handbrake or transmission shaft, handbrake fails; in case of failure of any part of air pump, pipeline, air reservoir and brake valve, foot brake fails. The air brake can effectively avoid these dangers
4、斷氣剎制動氣室內有個強 力彈簧,行車時壓縮空氣將彈簧頂起。手剎車就是把氣放掉,讓彈簧把剎車鎖死。行車中氣壓過低時也會產生剎車效應,保證安全。
4. There is a strong spring in the brake chamber of the air break brake, which is pushed up by compressed air when driving. The handbrake is to let the air out and let the spring lock the brake. When the air pressure is too low in driving, it will produce braking effect to ensure safety.
技術支持:濟南諾商  XML   TXT   
本網站部分資源來自互聯網,如有侵權,請聯系我們及時刪除
分享按鈕

截屏,微信識別二維碼

微信號:

點擊微信號復制,添加好友

 打開微信

日本阿v不卡高清在线播放_2019久久久高清456_被公每天都侵犯的我正在播放